شناورسازی به کمک هوای فشرده (DAF) یکی از پروسه های مهم تصفیه آب، پساب و فاضلاب های صنعتی می باشد که باعث زلال شدن پساب و فاضلاب به علت حذف انواع آلاینده های معلق از آن مانند روغن، گریس، چربی و ذرات کلوئیدی می شود. عملیات حذف آلاینده ها و ذرات کلوئیدی در این روش براساس تزریق هوای فشرده به پساب می باشد. دراثر این عمل، حباب های ریز آزاد شده به ذرات کلوئیدی معلق در فاضلاب چسبیده و باعث شناورشدن ذرات به سطح DAF می گردند که در آنجا توسط اسکیمر جمع آوری و به یک مخزن نگهداری لجن تخلیه میگردند. به منظور افزایش راندمان شناورسازی ذرات کلوئیدی، معمولا به پساب ورودی مواد منعقد کننده و کمک پلیمری جهت عملیات انعقاد و بی بار کردن ذرات اضافه می گردد. بدین منظور از لوله های مارپیچی استفاده می گردد که از یک طرف مواد منعقد کننده در بخش های مختلف تزریق می گردد و از طرف دیگر مخلوط هوا با مایع تحت فشار جهت اختلاط بهتر به داخل این لوله ها تزریق می گردد. در سیستم DAF مقداری از آب تمیز و شفاف شده به لوله های فلوکولاتور انتقال داده بخشی از آن نیز مستقیما به واحد شناورسازی انتقال داده می شود. آب اضافه تصفیه شده نیز از سیستم DAF خارج می گردد. زلال بودن آب خروجی از واحد DAF یکی از معیارهای کارکرد مناسب این سیستم می باشد. در بعضی موارد تانک های انعقاد و لخته سازی به جای لوله های فلوکولاتور مورد استفاده قرار می گیرند. در این حالت مواد منعقد کننده در یک فاصله زمانی حدود ۵ دقیقه با پساب در تانک انعقاد مخلوط می گردد و سپس به داخل DAF تزریق می شود. این فرایند هنگامی که پساب ورودی خنثی نمی باشد و به علت اینکه زمان کافی جهت خنثی سازی وجود دارد و از طرفی به راحتی توسط کاربر قابل کنترل می باشد نسبت به فلوکولاتورهای لوله ای برتری دارد.
Using compressed air flotation (DAF) is one of the most important processes for water, wastewater and industrial wastewater and sewage effluent is clear that the removal of suspended contaminants such as oil, grease, fat and colloidal particles can be . The removal of colloidal particles, and the method by injecting compressed air into the water. This is due, colloidal particles suspended in the wastewater released into tiny bubbles stuck, causing the particles to float to the surface where DAF are collected by Askymr a sludge storage tanks are emptied.
In order to increase the efficiency of flotation colloidal particles, usually effluent polymer coagulants and assistance for the operation and the time of conclusion of the particles is added. DAF system clean and clear some of the water pipes flocculates to transfer part of it is transferred directly to the flotation unit. DAF water treatment system is also out.
Clear water output from the DAF unit is a measure of the proper functioning of the system. In some cases, coagulation, flocculation tanks instead flocculates tubes are used. In this case concluded in a period of about 5 minutes and then mixed with water in the tank conclusion is injected into the DAF. The process is stopped when the effluent is not because there is not enough time to neutralize the other hand, is easily controlled by the user relative to pipe flocculates superior.
Sand filtration, chlorination stations, restaurants consuming fat, fat-soluble Gyr, pond pool Gyr, fat retention ponds Gyr, kitchen, kitchen-consuming fat tissue Gyr, fat, fat-consuming treatment, household consuming fat, fat waste water retention, fat retention industrial waste, consuming fat is fat stuck-wastewater
